Price List
    All prices are current as of January 2009.  Prices below may change as the industry increases or decreases its prices.
    ANDRUSS AUTOWORKS will quote you or your company the cost of repairs or service prior to work being done with the
    current industry rates.
    ANDRUSS AUTOWORKS
    Mobile Fleet Service
    can replace any of the following
    components:
  • Universal joints & yolks
  • Water pumps
  • Starter solenoids
  • Lamps
  • Bearings and seals
  • Radiator
  • Engines
  • Transmissions
  • Clutch / Complete
  • Alternators
  • Belt replacement
  • Batteries
  • Fuel pumps
  • Power steering pumps
  • Smog pumps
  • Rack & Pinion
  • Steering box replacement
  • Air conditioning service /
    compressor replacement
  • On-site welding available
    Oil Change $42.99
  • Remove and dispose of old oil and filter
  • Install FRAM filter and up to 5 qts. Castrol 20/50 W
  • Lube and inspect ball joints, pitman arm, idler arm
  • Parts included
    (Recommend service every 3,000 - 5,000 miles or 90 days)
    Diesel Oil Change     Labor starts at: $89.99
  • Remove and dispose of old oil and filter.
  • Install filter and Chevron Dello 15/40 W oil
  • Lube and inspect ball joints, pitman arm, idler arm
  • Filter, oil, and parts not included
    (Recommend service every 5,000 - 7,500 miles or 90 days)
    Safety Check $35.00
     3/4 Ton $47.50  /  1 Ton $65.00
  • Remove wheel (4), check all brakes
  • Adjust rear brakes / park brake
  • Check all belts for cracks
  • Load test battery and volt check alternator
  • Inspect and rotate tires
  • Top off all fluids; coolant, brake, transmission, windshield soap
  • FWD - check inner and outer constant velocity joint boots
  • Parts NOT included
    (Recommend service every 3,000 - 5,000 miles or 90 days)
    Tune-up V8 $129.99 / All Vans start at: $225.00
  • Replace: air filter, fuel filter, crank case breather filter, PCV valve, cap and rotor, spark
    plugs, plug wires
  • Set timing
  • Adjust carburetor (clean EFI throttle housing and butterfly if applicable)
  • Parts NOT included
    (Recommend service at 75,000 miles)
    Brake Service $129.99 (per axle)
    3/4 - 1 Ton Air Brakes* $190.00 (per axle)
  • Front: remove calipers, replace pads, and remove rotor and resurface replace spindle
    seals, inspect and repack bearings with high temperature grease

  • Rear: remove shoes, install hardware kit, install new shoes
    Parts NOT included                         *machining starts @ $19.00 each

    *Prepare drums, adjust emergency brake prices based on rotors and drums being
    within service limits (recommend service at 10% remaining - 90% wear)
    (Recommend service every 3,000 - 5,000 miles or 90 days)
    Rear Wheel Cylinder Replacement $95.00 each
  • Remove brake shoes and hardware
  • Remove line and wheel cylinder
  • Clean backing plate
  • Install new wheel cylinder
  • Bleed hydraulic line
  • Parts NOT included
    Machining per rotor* / drum starts at: $19.00
    *If rotors and or drums are within their “RUN-OUT” measurements
  • Machining will be performed
  • Surface rotors or drums on brake lathe
  • Press new grease seals
    Front Brake Caliper Rebuild $95.00 each
  • Remove caliper and line
  • Rebuild existing caliper
  • Remove caliper pistons
  • Resurface bore and piston skirt
  • Replace piston seal and dust seal
  • Bleed hydraulic line
  • Parts NOT included
    Complete Caliper Replacement $55.00 each
  • Remove caliper and line
  • Install brand new caliper - complete
  • Bleed hydraulic line
  • Parts NOT included
    A/C Clutch Bearing Replacement $129.99
  • Remove compressor body
  • Pull clutch assembly from compressor
  • Press failed bearing from shaft
  • Replace bearing and clutch assembly
  • Parts NOT included
    Transmission Service $129.99
  • Remove old ATF, remove pan, remove old filter
  • Replace filter, o-ring, pan gasket, and fill with Dexron or FA fluid*
  • Parts included
    *Prevent transmission failure
    (Recommend service twice a year)
    Brake Fluid Service $47.50
  • Drain all brake fluid
  • Flush and clean master cylinder reservoir
  • Refill system with fresh DOT 4 fluid and bleed entire system
  • Restore new brake feeling
  • Parts NOT included
    (Recommend service once a year)
    Axle Seal Replacement $120.00 (per wheel)
  • Remove wheel, hub/backing plate
  • Remove differential cover, axle pin, and horseshoe clips
  • Pull axles from housing
  • Pull axle seals / bearings - install new parts
  • Top off differential grease
  • Parts NOT included
    Air Conditioning Service $95.00
  • Evacuate system of all Freon
  • Evacuate evaporator of all liquid with vacuum
  • Install fresh ester / pag oil into A/C compressor
  • Install recycled / fresh refrigerant R-134a
  • Parts NOT included
    Cooling System Service $129.99
  • Pressure test radiator cap
  • Replace thermostat and gasket
  • Flush cooling system
  • Add PEAK anti-freeze
  • Parts included
    (Recommend service once a year)
    Air Conditioning Retrofit $190.00
  • Evacuate system of all Freon
  • Evacuate evaporator unit of all condensation with vacuum
  • Remove fittings on compressor and both pressure lines
  • Install new compatible R-134a fittings
  • Fill compressor with fresh Ester Oil (Oil charge)
  • Fill entire system with fresh R-134a Freon
    Half Shaft Replacement $95.00 (per shaft)
  • Remove wheel, caliper, hub, and strut
  • Press ball joints and tie rods
  • Remove half shaft from transmission
  • Replace shaft assembly
  • Align front wheel
  • Parts NOT included
    Tire Installation & Balance $47.50 per axle
    $95.00 per hour on large wheel assemblies (22.5 & 24.5 tubeless tires)
  • Remove wheels from vehicle
  • Remove tire from rim
  • Remove valve stem from rim
  • Install new tire and valve stem
  • Inflate to proper pressure
  • Complete computer digital spin balance
  • Parts NOT included
    Clutch Replacement - starts at: $375.00
  • Remove transmission
  • Replace pressure plate
  • Machine flywheel
  • Adjust and / or bleed clutch
  • Replace throwout bearing
  • Bleed hydraulic system (if applicable)
  • Replace clutch plate
  • Adjust cable, test drive
  • Replace pilot bearing
  • Parts included
    Alignment $139.99 (on most vehicles)
  • Measure & Adjust camber, castor, toe-in / toe-out
  • Test drive and remeasure
  • Install shims (if needed)
  • Parts included
    Electronic Control Module (ECM) Diagnostic Check & Test $95.00
  • MT 2500 scanner utilized to download and clear computer codes
  • Diagnostic checks also performed during vehicle operation “movie mode”
  • Oscilloscope used to test electrical systems and test individual components
  • Digital battery load tester
    Flat Tire Repair $18.00
    Chemical Patch $23.00
  • Remove tire
  • Plug or interior chemical patch tire
  • Re-inflate to recommended pressure
  • Parts included
    Complete Diagnostic Check $95.00
  • Compression test
  • Leak down test
  • Mechanical timing check
  • Identify bearing failure location
    Electrical Component Installation / Removal (Price Quoted Prior to Work)
  • Cellular phone & antenna
  • Two-way radio & antenna
  • Emergency light bars & spot lights
  • Parts NOT included